BQQBR - CHELANT DEMAND P-1 REAGENT, 504
- MSDS: BQQBR
- Manufacturer: BETZ LABORATORIES INC
- Product Name: CHELANT DEMAND P-1 REAGENT, 504
- National Stock Number: 6810-00N036931
Product Identification
Product ID:CHELANT DEMAND P-1 REAGENT, 504
MSDS Date:02/16/1991
FSC:6810
NIIN:00N036931
MSDS Number: BQQBR
Responsible Party
TREVOSE, PA 19047
US
Emergency Phone: 800-877-1940
Info Phone: 800-877-1940
Cage: 24774
Contractor
Telephone: 215-355-3300
Cage: 24774
Ingredients
SULFURIC ACID (SARA III)
CAS: 7664-93-9
RTECS: WS5600000
OSHA PEL 1 MG/M3
ACGIH TLV: 1 MG/M3
EPA Report Quantity: 1000 LBS
DOT Report Quantity: 1000 LBS
SODIUM FLUORIDE (SARA III)
CAS: 7681-49-4
RTECS: WB0350000
OSHA PEL 2.5 MG/M3 (F)
ACGIH TLV: 2.5 MG/M3 (F)
EPA Report Quantity: 1000 LBS
DOT Report Quantity: 1000 LBS
Hazards
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NO Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: CORROSIVE TO SKIN. EYE:
CORROSIVE TO EYES. INHALATION: MISTS/AEROSOLS CAUSE IRRITATION TO
UPPER RESPIRATORY TRACT. CHRONIC: PROLONGED OR REPEATED CONTACT MAY
CAUSE TISSUE NECROSIS. MAY BE TOXIC IF ORALLY INGESTED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:CAUSES SEVERE IRRITATION, BURNS OR TISSUE
ULCERATION WITH SUBSEQUENT SCARRING.
Medical Cond Aggravated by Exposure:NOT KNOWN.
First Aid
First Aid:SKIN:REMOVE CONTAMD CLTHG. WASH AREA W/LRG AMTS OF SOAP
SOLN/WATER FOR 15 MINS.IMMED CONT PHYS.EYE: IMMED FLUSH W/WATER FOR
AT LST 15 MINS. IMMED CONT PHYS FOR ADDNL TREATMENT. INHAL: REMOVE
VICTIM FR OM CONTAMD AREA. APPLY NEC FIRST AID TREATMENT. IMMED
CONT PHYS. REMOVE FROM EXPOS.SUPPORT BRTHG (GIVE ARTF RESP/OXYGEN)
. INGEST:GEN: DO NOT FEED ANYTHING BY MOUTH TO AN UNCON/CONVULS
(SUPDAT)
Fire Fighting
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM OR WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
Accidental Release
Spill Release Procedures:GEN: VENT AREA,USE SPECIFIED PROT
EQUIP.CONTAIN & ABSORB ON ABSORB MATL. PLACE IN WASTE DISP
CNTNR.WASTE CHARACT OF ABSORB MATL/ANY CONTAMD SOIL, SHOULD BE
DETERM I/A/W RCRA REGS.SPECIFIC: FLUSH AREA W/WATER.WET AREA MAY
BE SLIPPERY.SPREADSAND/GRIT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
Handling
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
DO NOT FREEZE. IF FROZEN, THAW AND MIX COMPLETELY PRIOR TO USE.
Other Precautions:CORROSIVE TO SKIN. CORROSIVE TO EYES.
Exposure Controls
Respiratory Protection:USE PROTECTIVE EQUIP I/A/W 29 CFR 1910.132-134.
USE NIOSH/MSHA APPRVD RESP W/IN USE LIMITATIONS/ELSE USE NIOSH/MSHA
APPRVD SUPP AIR RESPS.IF VENT IS INADEQ/SIGNIFICANT REAGENT EXPOS
IS LIKELY,USE NIOS H/MSHA APPRVD HIGH EFFICIENCY(SUPP DATA)
Ventilation:ADEQUATE VENTILATION TO MAINTAIN AIR CONTAMINANTS BELOW
EXPOSURE LIMITS.
Protective Gloves:GAUNTLET-TYPE NEOPRENE GLOVES.
Eye Protection:CHEM WORK GOG/FULL LGTH FACESHLD .
Other Protective Equipment:CHEMICAL RESISTANT APRON. EMERGENCY EYE BATH
AND DELUGE SHOWER.
Work Hygienic Practices:WASH OFF AFTER EACH USE. REPLACE AS NECESSARY.
Supplemental Safety and Health
FIRST AID PROCEDURES: VICTIM. SPECIFIC: DO NOT INDUCE VOMITING.
IMMEDIATELY CONTACT PHYSICIAN. DILUTE CONTENTS OF STOMACH USING 3-4
GLASSES OF MILK OR WATER. RESPIRATORY PROTECTION: PARTICULATE
CARTRI DGES.
Chemical Properties
HCC:C1
Spec Gravity:1.041 @ 70F
pH:4.2
Solubility in Water:100
Appearance and Odor:COLORLESS LIQUID, NO ODOR.
Stability
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION (DESTRUCTIVE
FIRES) YIELDS ELEMENTAL OXIDES.
Disposal
Waste Disposal Methods:GEN:WATER CONTAM W/REAGENT MAY BE SENT TO
SANITARY SEWER, I/A/W ANY FED, ST, & LOC AGREEMENT, A TREATMENT
FACILITY/DISCHARGED UNDER NPDES PERMIT.REAGENT (AS IS): INCIN/BURY
IN APPRVD LANDFILL. DISPOSE OF IN ACCORDANCE WITH FED, ST, & LOC
REGS .
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.